Utilization of Waste Banana Peels and Corn Cobs as Substrates in Neurospora sitophila Fermentation for Production of Natural Yellow Dyes

Aida Nur Ramadhani, Listia Aulia Ruwaidah, Halimah Madania Rahman, Nadya Khoirun Nisa, Intan Septiya, Endang Kwartiningsih

Abstract


In the current situation, biomass gasification has become a major interest in producing clean energy and green chemicals. By gasification, the biomass can be converted to synthetic gas (syngas) for many purposes. However, syngas with high tar content can cause pipeline fouling and disturb the operation of downstream equipment. To reduce tar content, a two-series wet scrubber was installed for syngas cleaning produced by palm kernel shell gasification. Firstly, the gasification is operated at a temperature range of 500 – 600oC and 700 – 800oC to determine the conditions where the lowest tar syngas is produced. After that, the wet scrubber is installed with a variety of solvents including isopropyl alcohol, water, used cooking oil, and used lubricating oil. The results show that the lowest tar syngas was produced at a temperature of 800oC with a tar yield of 0.165 g/kg biomass. Meanwhile, in the same condition, isopropyl alcohol delivers the most substantial impact on tar removal efficiency, whereas used lubricating oil results in less impact. The use of isopropyl alcohol resulted in 99.25% tar removal effectiveness while lubricating oil yielded just 50.32%.


Keywords


corncob, banana peel, natural dyes, solid state fermentation, Neurospora sitophila, carotenoid pigments

Full Text:

PDF

References


Alzate Acevedo, S., Díaz Carrillo, Á. J., Flórez-López, E., & Grande-Tovar, C. D. (2021). Recovery of Banana Waste-Loss from Production and Processing: A Contribution to a Circular Economy. Molecules (Basel, Switzerland), 26(17), 1–30. https://doi.org/10.3390/molecules26175282

Anshori, M., Jafar, R. M., Lestari, D., & Kresnowati, M. T. A. P. (2022). Production of Carotenoids from Oil Palm Empty Fruit Bunches: Selection of Extraction Methods. Journal of Engineering and Technological Sciences, 54(3). https://doi.org/10.5614/j.eng.technol.sci.2022.54.3.3

Aprilia, A., Kurniawati, E., Kedokteran, F., Lampung, U., Molekuler, B. B., Kedokteran, F., & Lampung, U. (2016). Pengaruh Beta Karoten pada Kulit Pisang Kepok dalam Mencegah Infark Miokard Akut The Influence Effect of Beta Carotene on The Banana Peel in Preventing Acute Myocardial Infarction. Majority, 5(4), 2–6.

Ardila-Leal, L. D., Poutou-Piñales, R. A., Pedroza-Rodríguez, A. M., & Quevedo-Hidalgo, B. E. (2021). A brief history of colour, the environmental impact of synthetic dyes and removal by using laccases. Molecules, 26(13). https://doi.org/10.3390/molecules26133813

Aruldass, C. A., Dufossé, L., & Ahmad, W. A. (2018). Current perspective of yellowish-orange pigments from microorganisms- a review. Journal of Cleaner Production, 180, 168–182. https://doi.org/10.1016/j.jclepro.2018.01.093

Ashok Kumar, K., Gousia, S. K., & Latha, J. N. L. (2015). Evaluation of biological activity of secondary metabolites of Neurospora crassa from machilipatnam sea water. Research Journal of Microbiology, 10(8), 377–384. https://doi.org/10.3923/jm.2015.377.384

Badan Pusat Statistik. (2020a). Horticultural Statistics 2021. https://www.bps.go.id/publication/2022/06/08/44e935e8c141bcb37569aed3/horticultural-statistics-2021.html

Badan Pusat Statistik. (2020b). The 2021 Analysis of Maize and Soybean Productivity in Indonesia. 2020. https://www.bps.go.id/publication/2022/12/16/9e87d65dae851717a1af5784/analisis-produktivitas-jagung-dan-kedelai-di-indonesia-2021.html

Chilakamarry, C. R., Mimi Sakinah, A. M., Zularisam, A. W., Sirohi, R., Khilji, I. A., Ahmad, N., & Pandey, A. (2022). Advances in solid-state fermentation for bioconversion of agricultural wastes to value-added products: Opportunities and challenges. Bioresource Technology, 343, 126065. https://doi.org/https://doi.org/10.1016/j.biortech.2021.126065

Damayanti, J., Azmilia, R., Ainun, Z., R., N. A., & Nurdin, M. I. (2021). Isolation of Lycopene Component from Tamarillo (Solanum betaceum). Indonesian Journal of Chemical Research, 9(2 SE-Research articles). https://doi.org/10.30598//ijcr.2020.9-dam

Dekker, R. F. H. (1980). Induction and characterization of a cellobiose dehydrogenase produced by a species of Monilia. Journal of General Microbiology, 120(2), 309–316. https://doi.org/10.1099/00221287-120-2-309

Farawahida, A. H., Palmer, J., & Flint, S. (2022). Monascus spp. and citrinin: Identification, selection of Monascus spp. isolates, occurrence, detection and reduction of citrinin during the fermentation of red fermented rice. International Journal of Food Microbiology, 379(July), 109829. https://doi.org/10.1016/j.ijfoodmicro.2022.109829

Forgacs, E., Cserháti, T., & Oros, G. (2004). Removal of synthetic dyes from wastewaters: a review. Environment International, 30(7), 953–971. https://doi.org/https://doi.org/10.1016/j.envint.2004.02.001

Gandam, P. K., Chinta, M. L., Gandham, A. P., Pabbathi, N. P. P., Konakanchi, S., Bhavanam, A., Atchuta, S. R., Baadhe, R. R., & Bhatia, R. K. (2022). A New Insight into the Composition and Physical Characteristics of Corncob—Substantiating Its Potential for Tailored Biorefinery Objectives. Fermentation, 8(12). https://doi.org/10.3390/fermentation8120704

Gmoser, R., Ferreira, J. A., Lennartsson, P. R., & Taherzadeh, M. J. (2017). Filamentous ascomycetes fungi as a source of natural pigments. Fungal Biology and Biotechnology, 4(1), 1–25. https://doi.org/10.1186/s40694-017-0033-2

Gmoser, R., Ferreira, J. A., Lundin, M., Taherzadeh, M. J., & Lennartsson, P. R. (2018). Pigment production by the edible filamentous fungus Neurospora intermedia. Fermentation, 4(1). https://doi.org/10.3390/fermentation4010011

Gmoser, R., Sintca, C., Taherzadeh, M. J., & Lennartsson, P. R. (2019). Combining submerged and solid state fermentation to convert waste bread into protein and pigment using the edible filamentous fungus N. intermedia. Waste Management, 97, 63–70. https://doi.org/10.1016/j.wasman.2019.07.039

Hagos, M., Redi-Abshiro, M., Chandravanshi, B. S., & Yaya, E. E. (2022). Development of Analytical Methods for Determination of β-Carotene in Pumpkin (Cucurbita maxima) Flesh, Peel, and Seed Powder Samples. International Journal of Analytical Chemistry, 2022, 9363692. https://doi.org/10.1155/2022/9363692

Hassimi, A. H., Ezril Hafiz, R., Muhamad, M. H., & Sheikh Abdullah, S. R. (2020). Bioflocculant production using palm oil mill and sago mill effluent as a fermentation feedstock: Characterization and mechanism of flocculation. Journal of Environmental Management, 260(December 2019), 110046. https://doi.org/10.1016/j.jenvman.2019.110046

Jhondri, J., Abun, A., Rusmana, D., & Wiradimadja, R. (2017). BINDERING AND THE STABILITY OF BETA CAROTEN FROM Neurospora sitophila. XXI, 143–148.

Jing, Y., Wang, J., Gao, H., Jiang, Y., Jiang, W., Jiang, M., Xin, F., & Zhang, W. (2023). Enhanced β-carotene production in Yarrowia lipolytica through the metabolic and fermentation engineering. Journal of Industrial Microbiology & Biotechnology, 50(1). https://doi.org/10.1093/jimb/kuad009

Jodiawan, Chrisdiyanti, D. N., Vi’atin, N., Prihastyanti, M. N. U., Chandra, R. D., Heriyanto, Siswanti, C. A., Hapsari, L., & Brotosudarmo, T. H. P. (2021). Carotenoid analysis from commercial banana cultivars (Musa spp.) in malang, east java, indonesia. Indonesian Journal of Chemistry, 21(3), 690–698. https://doi.org/10.22146/ijc.60865

Kapoor, M., Panwar, D., & Kaira, G. S. (2016). Bioprocesses for Enzyme Production Using Agro-Industrial Wastes: Technical Challenges and Commercialization Potential. In Agro-Industrial Wastes as Feedstock for Enzyme Production: Apply and Exploit the Emerging and Valuable Use Options of Waste Biomass. Elsevier Inc. https://doi.org/10.1016/B978-0-12-802392-1.00003-4

Kaur, P., Ghoshal, G., & Jain, A. (2019). Bio-utilization of fruits and vegetables waste to produce β-carotene in solid-state fermentation: Characterization and antioxidant activity. Process Biochemistry, 76, 155–164. https://doi.org/https://doi.org/10.1016/j.procbio.2018.10.007

Kavitha, R., Aiswariya, S., & Ratnavali, C. M. G. (2010). Anticancer activity of red pigment from Serratia marcescens in human cervix carcinoma. International Journal of PharmTech Research, 2, 784–787.

Kresnowati, M. T. A. P., Lestari, D., Anshori, M., & Jafar, R. M. (2020). Production of carotenoids from oil palm empty fruit bunches. IOP Conference Series: Earth and Environmental Science, 460(1). https://doi.org/10.1088/1755-1315/460/1/012025

Kwartiningsih, E., Ramadhani, A. N., Putri, N. G. A., & Damara, V. C. J. (2021). Chlorophyll Extraction Methods Review and Chlorophyll Stability of Katuk Leaves (Sauropus androgynous). Journal of Physics: Conference Series, 1858(1), 12015. https://doi.org/10.1088/1742-6596/1858/1/012015

Lau, T., Harbourne, N., & Oruña-Concha, M. J. (2019). Valorisation of sweet corn (Zea mays) cob by extraction of valuable compounds. International Journal of Food Science and Technology, 54(4), 1240–1246. https://doi.org/10.1111/ijfs.14092

Lellis, B., Fávaro-Polonio, C. Z., Pamphile, J. A., & Polonio, J. C. (2019). Effects of textile dyes on health and the environment and bioremediation potential of living organisms. Biotechnology Research and Innovation, 3(2), 275–290. https://doi.org/10.1016/j.biori.2019.09.001

Liu, J., Wu, J., Cai, X., Zhang, S., Liang, Y., & Lin, Q. (2021). Regulation of secondary metabolite biosynthesis in Monascus purpureus via cofactor metabolic engineering strategies. Food Microbiology, 95(October 2020), 103689. https://doi.org/10.1016/j.fm.2020.103689

Liu, Y., Yu, Z., Zhang, Y., & Wang, H. (2021). Microbial dyeing for inoculation and pigment used in wood processing: Opportunities and challenges. Dyes and Pigments, 186(September 2020), 109021. https://doi.org/10.1016/j.dyepig.2020.109021

Louhasakul, Y., Wado, H., Lateh, R., & Cheirsilp, B. (2023). Solid-state fermentation of Saba banana peel for pigment production by Monascus purpureus. Brazilian Journal of Microbiology, 54(1), 93–102. https://doi.org/10.1007/s42770-022-00866-3

Margono, M., Paryanto, P., Aida Nur, R., & Ainur, R. (2022). ANEKA SUMBER PEWARNA ALAMI Proses Produksi dan Aplikasinya untuk Pewarnaan Batik. Penerbit Lakeisha. https://books.google.co.id/books?id=p5SjEAAAQBAJ&lpg=PA1&ots=bne1zUxQo7&dq=info%3AYZHmOHcDevsJ%3Ascholar.google.com&lr&pg=PA1#v=onepage&q&f=false

Margono, M., Paryanto, P., Hanifa, V., & Abimanyu, C. (2021). Production of Natural Colorant by Monascus Purpureus FNCC 6008 using Rice and Cassava as Carbon Substrates. Jurnal Bahan Alam Terbarukan, 10(1), 24–30. https://doi.org/10.15294/jbat.v10i1.30486

Maxwell, O. I., Chinwuba, U. B., & Onyebuchukwu, M. G. (2019). Protein Enrichment of Potato Peels Using Saccharomyces cerevisiae via Solid-State Fermentation Process. Advances in Chemical Engineering and Science, 09(01), 99–108. https://doi.org/10.4236/aces.2019.91008

Moh, M. H., Che Man, Y. B., Badlishah, B. S., Jinap, S., Saad, M. S., & Abdullah, W. J. W. (1999). Quantitative Analysis of Palm Carotene Using Fourier Transform Infrared and Near Infrared Spectroscopy. JAOCS, Journal of the American Oil Chemists’ Society, 76(2), 249–254. https://doi.org/10.1007/s11746-999-0226-9

Narsing Rao, M. P., Xiao, M., & Li, W. J. (2017). Fungal and bacterial pigments: Secondary metabolites with wide applications. Frontiers in Microbiology, 8(JUN), 1–13. https://doi.org/10.3389/fmicb.2017.01113

Neha, T., Shishir, T., & Ashutosh, D. (2017). Fourier transform infrared spectroscopy (FTIR) profiling of red pigment produced by Bacillus subtilis PD5. African Journal of Biotechnology, 16(27), 1507–1512. https://doi.org/10.5897/ajb2017.15959

Numan, M., Bashir, S., Mumtaz, R., Tayyab, S., Rehman, N. U., Khan, A. L., Shinwari, Z. K., & Al-Harrasi, A. (2018). Therapeutic applications of bacterial pigments: a review of current status and future opportunities. 3 Biotech, 8(4). https://doi.org/10.1007/s13205-018-1227-x

O’Hare, T. J., Fanning, K. J., & Martin, I. F. (2015). Zeaxanthin biofortification of sweet-corn and factors affecting zeaxanthin accumulation and colour change. Archives of Biochemistry and Biophysics, 572, 184–187. https://doi.org/10.1016/j.abb.2015.01.015

Pandey, A. (2003). Solid-state fermentation. Biochemical Engineering Journal, 13(November 2001), 81–84.

Panesar, R., Kaur, S., & Panesar, P. S. (2015). Production of microbial pigments utilizing agro-industrial waste: A review. Current Opinion in Food Science, 1(1), 70–76. https://doi.org/10.1016/j.cofs.2014.12.002

Paul Letelay, O., Hiariej, A., & Pesik, A. (2020). Analisis Beta Karoten dan Vitamin pada Kulit dan Daging Buah Pisang Tongka Langit (Musa Troglodytarum L.) di Kota AmbonAROTEN DAN VITAMIN PADA KULIT DAN DAGING BUAH PISANG TONGKA LANGIT (Musa troglodytarum L.) DI KOTA AMBON. Jurnal Agritechno, 13(1), 24–33. https://doi.org/10.20956/at.v13i1.243

Pea, S. I., Khairuddin, & Prismawiryanti. (2020). Studi Perbandingan Aktivitas Antioksidan Xantofil dan Karoten Kapang Oncm Merah pada Berbagai Waktu Inkubasi. KOVALEN: Jurnal Riset Kimia, 6(2), 152–157. https://doi.org/10.22487/kovalen.2020.v6.i2.11547

Pereira, A., & Maraschin, M. (2015). Banana (Musa spp) from peel to pulp: Ethnopharmacology, source of bioactive compounds and its relevance for human health. Journal of Ethnopharmacology, 160, 149–163. https://doi.org/10.1016/j.jep.2014.11.008

Phillips, C. M., Beeson, W. T., Cate, J. H., & Marletta, M. A. (2011). Cellobiose Dehydrogenase and a Copper-Dependent Polysaccharide Monooxygenase Potentiate Cellulose Degradation by Neurospora crassa . ACS Chemical Biology, 6(12), 1399–1406. https://doi.org/10.1021/cb200351y

Rana, B., Bhattacharyya, M., Patni, B., Arya, M., & Joshi, G. K. (2021). The Realm of Microbial Pigments in the Food Color Market. Frontiers in Sustainable Food Systems, 5(March 2021), 1–14. https://doi.org/10.3389/fsufs.2021.603892

Saha, N., Samanta, A. K., Chaudhuri, S., & Dutta, D. (2015). Characterization and antioxidant potential of a carotenoid from a newly isolated yeast. Food Science and Biotechnology, 24(1), 117–124. https://doi.org/10.1007/s10068-015-0017-z

Said, S. D., Pontas, K., Thaib, A., Maimun, T., & Silvianti, C. (2022). Increasing Crude Protein Content of Sago Dregs Through Solid State Fermentation Process. Journal of Applied Technology, 9(1), 1–6.

Savitri, D., Djawad, K., Hatta, M., Wahyuni, S., & Bukhari, A. (2022). Active compounds in kepok banana peel as anti-inflammatory in acne vulgaris: Review article. Annals of Medicine and Surgery, 84(October), 104868. https://doi.org/10.1016/j.amsu.2022.104868

Seno Aulia, A., Nur Asni, S., Anggi, R., Landiyani, P., & Eka, N. (2019). PEMANFAATAN AIR KELAPA DAN LIMBAH KECAP SEBAGAI SUBSTRAT DALAM PRODUKSI PIGMEN KAROTENOID. Jurnal Sains Dan Teknologi Farmasi Indonesia, 8(2), 48–59.

Singgih, M., Andriatna, W., Damayanti, S., & Priatni, S. (2015). Carotenogenesis Study of Neurospora intermedia N-1 in liquid substrate fermentation. Journal of Chemical and Pharmaceutical Research, 7(5), 842–847.

Slama, H. Ben, Bouket, A. C., Pourhassan, Z., Alenezi, F. N., Silini, A., Cherif-Silini, H., Oszako, T., Luptakova, L., Golińska, P., & Belbahri, L. (2021). Diversity of synthetic dyes from textile industries, discharge impacts and treatment methods. Applied Sciences (Switzerland), 11(14), 1–21. https://doi.org/10.3390/app11146255

Wang, E., Dong, C., Zhang, P., Roberts, T. H., & Park, R. F. (2021). Carotenoid biosynthesis and the evolution of carotenogenesis genes in rust fungi. Fungal Biology, 125(5), 400–411. https://doi.org/10.1016/j.funbio.2020.12.005

Zou, Y., Fu, J., Chen, Z., & Ren, L. (2021). The effect of microstructure on mechanical properties of corn cob. Micron, 146(March), 103070. https://doi.org/10.1016/j.micron.2021.103070




DOI: https://doi.org/10.23955/rkl.v19i1.33570

Article Metrics

Abstract view : 22 times
PDF - 14 times

Refbacks

  • There are currently no refbacks.


Copyright (c) 2024 Aida Nur Ramadhani, Listia Aulia Ruwaidah, Halimah Madania Rahman, Nadya Khoirun Nisa, Intan Septiya, Endang Kwartiningsih

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

JURNAL REKAYASA KIMIA & LINGKUNGAN

Jurusan Teknik Kimia Universitas Syiah Kuala, Jl. Tgk. Syech Abdur Rauf No.7, Kopelma Darussalam, Banda Aceh, INDONESIA

 

PRINCIPAL CONTACT

Nasrul Arahman, Prof. Dr. S.T., M.T.
Phone: +62813-6092-7917
E-mail: rkl@che.usk.ac.id, nasrular@usk.ac.id

 

SUPPORT CONTACT

Mirna Rahmah Lubis
E-mail: mirna@che.usk.ac.id
Wahyu Rinaldi, ST, M.Sc.
E-mail: wahyu.rinaldi@che.usk.ac.id

 

VISITORS